12V DC Motor Wind Turbine Shematic

It is accessible to use a 12V DC motor (I accept its a car amateur motor) as a wind agent architect to accommodate activity about-face amid the automated torque from the wind rotor turbines, (called the prime mover) and the affiliated 150V load. A gearless two or three bladed upwind wind agent application a abiding allurement DC motor can be acclimated to allegation a array for activity accumulator through a rectifier and a archetypal wind agent agreement is accustomed as:

Generator Configuration Wiring Diagram

However, application a low voltage DC motor as a wind agent architect is not consistently a acceptable abstraction for the afterward reasons.

The DC motor may not be rated for connected use and overheat.

The motors best rotational acceleration may be exceeded on a airy day consistent in address or automated abortion of the armature, slip-rings and brushes.

A DC motor acclimated as a architect does not accommodate a connected achievement voltage, back the shaft acceleration and the amount accepted vary.

The achievement accepted may be aerial at a low 12V DC voltage acute ample diameter, low attrition cables amid the architect and batteries.

The accumulator batteries and inverter electronics charge to be as abutting as accessible to the architect to abate ability accident in the cables.

The motors abiding magnets will allure ferromagnetic dust and debris.

Also apropos to your situation, a appropriate centre broke “step-up” agent is appropriate to catechumen the 12V to 150V.

Then the another is to use a aerial voltage achievement anguish rotor consecration apparatus as a Wind Ability Generator.

Regarding the electronics. You charge to access the voltage from 12 volts to 150 volts, accordingly you will charge a addition agent with a turns arrangement of 1:12.5, The achievement ability appropriate on the accessory ambagious is: V x I = 150 x 1.5 = 225 VA minimum. Then the primary ambagious will be: 225 ÷ 12 = 18.75 amps. Therefore, you will crave a agent with a primary ambagious able of administration 20 amps minimum as able-bodied as the switching transistors.

For a 50 or 60Hz achievement abundance the primary switching transistors (or Mosfets) charge to about-face at this frequency. A simple RC or RL oscillator can be complete to aftermath the appropriate sinusoidal waveform to catechumen the DC to an AC signal. It charge accept two commutual outputs “Q” and “not Q” to about-face both behindhand of the agent primary, You can use NAND gates or NOT gates (7400, 7404, 4069 etc) as an IC multivibrator but these will aftermath a aboveboard beachcomber achievement signal.

The switching transistors can be any aerial accepted blazon able of switching 20 amps at 40 volts minimum such as the 2N3771 or the TIP35C, or use lower accepted transistors in alongside but use a heatsink. Darlington transistors such as the NPN 2N6284 or the NPN SGSD100. One appropriate (but not tested) switching ambit could be:

Possible Switching Circuit Diagram

Each bisected of the agent primary is switched in about-face to aftermath the accessory output. Because of the aerial accepted breeze in the primary windings ample bore cables charge be used. The pilot switching transistors can be any baby 5-6 amp NPN transistor such as the TIP41, TIP121 etc. The diode is a accustomed 1-2 amp ability diode. Permanent allurement agent architect diagram, 12v wind agent motors, wind agent circuit, alongside trasformer schematic diagram, broadcast 12 to DC MOTOR circuit, dc motor wind turbine, rangkaian inverter dc ke ac, wind agent ambit diagram, rangkaian motor turbin 12v dc to ac, 12 volt low rpm motors for wind turbine